2022 Hyundai Santa Cruz engine problems

Related recalls

• 22V197000 · Engine And Engine Cooling › Engine › Gasoline › Turbo/Supercharger

  Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe and Santa Cruz vehicles. The oil supply pipe to the turbocharger may crack, which could result in an oil leak in the engine compartment.…

Recall repairs are free at authorized dealers. Confirm by VIN at nhtsa.gov/recalls.

What owners report

• “Vehicle intermittently drops into a “Limp Mode” while driving. Speed becomes restricted at 20 mph and engine RPM locks at 2000 RPM. Cannot accelerate when pressing on gas pedal. No engine lights come on when this occurs. Turning ignition off and restarting temporarily resets the computer and clears speed cap. Has happened 4 times since purchased. Has strong coolant smell and occasionally rotten egg smell. This is a safety hazard! Dealership has offered no solution other than if it happens again …”

  NHTSA complaint · filed 11/05/2026

• “I have had one Transmission and the tow hitch wiring harness replaced once from recalls. The tow hitch wiring harness is failing and all the warning lights are failing. The transmission is slipping upon takeoff and will rev at elevated RMS on the highway at times. When in reverse it will still move forward at times and on a hill it rolls back. The breaks have slammed on (for no reason) a couple of times while on the highway. It has also lost power. No check engine lights are on at this time. The…”

  NHTSA complaint · filed 09/27/2026

• “My INTEGRATED THERMAL MANAGEMENT (ITM) module went bad in my 2022 Hyundai Santa Cruz. I notified Hyundai about it and found out there are several service bulletins related to this part. My truck was outside the bumper-to-bumper warranty, so I had to pay over $1000.00 to get it replaced. I think it's shitty that Hyundai knows there is an issue with part on 2022-2023 Santa Cruz's and aren't willing to cover it. On top of that, the ECU has to re-calibrated after the repair, which didn't allow me to…”

  NHTSA complaint · filed 09/10/2026

• “October 2025 while driving the vehicle at highway speeds, vehicle started bucking, losing power and then stalled. The check engine light did not come on. I was able to get off the side of the road and had it towed to the dealer. Dealer found injectors to be leaking and replaced all 4 GDI fuel injectors-mileage was 29,598. On July 1, 2026, again the same issue while driving the vehicle at highway speeds, it started bucking, losing power and stalling when slowed. This time the check engine light c…”

  NHTSA complaint · filed 07/10/2026

• “While driving my vehicle on a two-lane highway, I experienced multiple sequential electronic system failures (including the vehicle no longer detecting the smart key), and all electronic systems on the car became inoperative. I lost all instrumentation, including my speedometer and tachometer. At the same time, I also experienced a loss of motive power, and the engine of the vehicle began running extremely erratically before completely cutting off. I attempted to make a safe stop on the side of …”

  NHTSA complaint · filed 06/21/2026

• “"The 8-speed Dual Clutch Transmission and engine (Cylinder 4) failed on my 2022 Hyundai Santa Cruz SEL Premium AWD with 37,780 miles. Both components are available for inspection upon request. While merging onto the highway in Sport Mode, the vehicle experienced violent shuddering and noise so severe I believed I had multiple flat tires simultaneously — specifically both front and rear passenger side tires. I immediately activated hazard lights and exited the highway. I was unable to safely oper…”

  NHTSA complaint · filed 03/26/2026

• “The contact owns a 2022 Hyundai Cruz. The contact stated that while driving 70 MPH, the vehicle lost motive power but was unable to accelerate above 30 MPH. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. After investigat…”

  NHTSA complaint · filed 11/04/2025

• “Vehicle began running roughly. CEL came on. Began to misfire. Limped it off the FWY under limited power. Had vehicle towed to dealership. Was diagnosed as having bad fuel injectors. Was told by service writer that Hyundai Santa Cruz trucks have been experiencing a lot of injector failures. Looking at the various Hyundai Santa Cruz forums, it appears that this has been a very common issue and has occurred in 2022 through 2025 model year vehicles”

  NHTSA complaint · filed 08/11/2025

Unverified owner reports from NHTSA's public complaint database.

Check the one you're looking at

A free VIN report shows recalls that may apply, the 5-year cost, and whether it fits your budget. Then ask our AI about this exact problem.