2022 Kia EV6 electrical system problems

Related recalls

• 24V867000 · Electrical System › 12v/24v/48v Battery

  Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.…

• 24V200000 · Electrical System › 12v/24v/48v Battery

  Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.…

• 26V431000 · Electrical System › Propulsion System › Traction Battery

  Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.…

Recall repairs are free at authorized dealers. Confirm by VIN at nhtsa.gov/recalls.

What owners report

• “2022 KIA EV6 ICCU failure. Car stopped Level 1 and Level 2 charging. Dealer confirmed failure and replaced under warranty. This was the best of the failure modes, we were not stranded and the 12v battery continued to the charged. Thanks.”

  NHTSA complaint · filed 10/19/2026

• “On Sunday, October 4, 2026, the vehicle lost drive power while I was operating it. At the same time, steering became extremely difficult and the brakes required extraordinary physical force to apply. I had to use all of my strength to safely bring the vehicle to a stop. At that point we were stranded in the #2 lane of travel. This was not a minor inconvenience or an isolated warning light; it was a serious roadway safety event. Had my wife been driving, I do not believe she would have had the ph…”

  NHTSA complaint · filed 10/08/2026

• “The ICCU, or integrated charge control unit, continually fails on this car. When it fails, the 12V battery rapidly drains and the car goes into turtle mode (25mph max) until the 12 battery drains completely. This has happened 4 times on this car, twice since I purchased it 'certified pre-owned" from a Kia dealership in February 2026. Luckily for me the two times it has failed on me, I was in town and close to home. I purchased this car to use for road trips, and out in remote areas of wilderne…”

  NHTSA complaint · filed 09/08/2026

• “I began to drive. The dashboard display read "Check low voltage supply" or something like that and on the opposite side of the display there was a small image that looks like a 12V battery. A moment later the dashboard display changed to read "DO NOT DRIVE." The car was towed to a dealer who reported a "failed ICCU and High Voltage Fuse." The vehicle was towed to a dealership where it is being repaired under warranty. The same parts were replaced on December 26, 2024, that time because the elec…”

  NHTSA complaint · filed 08/13/2026

• “Vehicle Safety Complaint My Kia experienced an ICCU (Integrated Charging Control Unit) failure and was at the dealership for approximately two months while awaiting repairs. The ICCU and related components were replaced, and I was told the vehicle had been repaired. However, immediately after I received the vehicle back, the “Check Electric Vehicle System” warning illuminated again. Since that time, the vehicle has continued to experience serious electrical issues. The vehicle has unexpectedl…”

  NHTSA complaint · filed 07/28/2026

• “1. Severe Safety Concerns (Battery Thermal Risk & Component Interdependency) The PTC (Positive Temperature Coefficient) heater in my vehicle has failed. This component failure has completely disabled my vehicle’s air conditioning (AC) system. In the Kia EV6 architecture, the AC compressor loop is not merely a cabin comfort feature; it is intrinsically linked to the vehicle's thermal management system responsible for cooling the high-voltage traction battery pack. California temperatures are proj…”

  NHTSA complaint · filed 07/04/2026

• “ICCU failure caused charger circuit breaker to trip due to sudden fault current situation”

  NHTSA complaint · filed 06/30/2026

• “The contact owns a 2022 Kia EV6. The contact stated that while driving approximately 6-7 MPH in the left-turn lane, the vehicle made an abnormal popping sound and stalled. The vehicle was pushed to the side of the road with assistance. The vehicle failed to restart and was towed to the dealer, where it was diagnosed with Integrated Charging Control Unit (ICCU) failure. The ICCU was replaced, and the vehicle was repaired; however, the failure recurred several times. Additionally, the contact stat…”

  NHTSA complaint · filed 06/30/2026

Unverified owner reports from NHTSA's public complaint database.

Check the one you're looking at

A free VIN report shows recalls that may apply, the 5-year cost, and whether it fits your budget. Then ask our AI about this exact problem.