2018 Mazda CX-9 engine problems

What owners report

• “While driving at highway speed in heavy rain the oil light suddenly came on followed within 30 seconds by an urgent need to immediately stop the car due to overheating. There was no radiator fluid left due to the sudden and catastrophic structural failure caused by a known manufacturing defect. Mazda calls it csp-11. They did NOT do a recall even though a situation such as this is clearly life-threatening. They offer an extended warranty to fix the problem fully up to 120,000 miles. Our car has …”

  NHTSA complaint · filed 09/17/2026

• “My 2018 Mazda Cx-9 equipped with the skyactiv-g 2.5T developed a serious cylinder-head/cooling-system failure. The vehicle began to lose coolant with no apparent external leak and subsequently displayed and engine -overheating warning. It continued to lose coolant after a flush. The Mazda dealership inspected the vehicle and diagnosed a warped cylinder head; I was also advised that the engine oil was milky, indicating coolant contamination. The affected component is the engine cylinder head/cool…”

  NHTSA complaint · filed 09/15/2026

• “I was driving home from work and may car started overheating out of nowhere. I was stuck in traffic and white smoke was exiting my exhaust. I pulled over and all of my coolant leaked out of my car. Took it the shop and they said I had a cracked head and need a whole new engine. I seen that there was a warranty sent out for a problem with an exhaust manifold issue leaking coolant and that is exactly what caused my problem. I contacted Mazda and they said there is nothing they can do. I will have …”

  NHTSA complaint · filed 08/08/2026

• “The cylinder head on this 2018 Mazda CX-9 (Skyactiv-G 2.5T engine) cracked, allowing engine coolant to leak and intermix with engine oil, causing loss of coolant and catastrophic engine failure. The vehicle became undriveable in the first week of November 2025 at approximately 125,019 miles and has remained inoperable since; it was not in a crash and had to be towed. This matches a known, documented defect on Mazda's Skyactiv-G 2.5T engine: coolant leakage at the cylinder head near the exhaust …”

  NHTSA complaint · filed 07/15/2026

• “My wife was driving the vehicle when the emergency lights started going off. She had to pull over because the car wouldn't run and said it was overheated. All the maintenance has been done to the car. We took it to the dealership and they said it is a cracked head and it is a known issue. They even issued a extended warranty for it. It is TSB 01-002/23. There should be a recall on this not just a partial credit.”

  NHTSA complaint · filed 06/05/2026

• “My 2018 Mazda CX-9 experienced catastrophic engine damage after a radiator failure allowed coolant to enter the engine. The vehicle provided no dashboard warning, overheating alert, or coolant warning before the failure occurred. Modern vehicles are designed to alert drivers to overheating or cooling system failures. The lack of warning prevented me from addressing the issue and resulted in catastrophic engine damage. I believe this represents a potential safety defect in the vehicle’s cooling s…”

  NHTSA complaint · filed 03/12/2026

• “Here the facts, bought a car out of state (Illinois) from Iowa with 130,131 miles on Sept 12th 2025, Mazda CX9, the dealer did not disclose any problems with the car, after 3 months of ownership, the car overheats on highway whit family including a [XXX] infant, white smoke under the hood and exhaust pipe, towed home, radiator was replaced, few days after that a coolant leak, vehicle was sent to an authorized Mazda dealership for diagnose, the technician told us, according to Mazda procedures,…”

  NHTSA complaint · filed 02/05/2026

• “. In January 2024, I purchased a used 2018 Mazda CX-9. The vehicle ran well until [XXX], when I discovered an engine coolant leak. My mechanic diagnosed it as a known defect involving the cylinder head. My husband contacted Mazda Customer Service (CS), and they advised us to get an official diagnosis from a Mazda dealer. We brought the car to Orland Park Mazda, where a diagnostic confirmed the defect (report attached). We later received an email from Mazda CS saying that since our car was at th…”

  NHTSA complaint · filed 07/21/2025

Unverified owner reports from NHTSA's public complaint database.

Check the one you're looking at

A free VIN report shows recalls that may apply, the 5-year cost, and whether it fits your budget. Then ask our AI about this exact problem.