2015 RAM 2500 engine problems

Related recalls

• 17V562000 · Engine And Engine Cooling › Engine › Diesel

  Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.…

Recall repairs are free at authorized dealers. Confirm by VIN at nhtsa.gov/recalls.

What owners report

• “On two separate occasions, once in 2025 and again in July 2026, while pulling a travel trailer an emissions control fault in the EGR system caused the Cummins turbo diesel engine in the truck to lose power. At this reduced power, highway speeds could not be maintained, and even small hills were difficult to climb. This is a significant safety problem, and the dealerships could not provide a timely repair due to lack of parts availability. The manufacturer of software in the engine control system…”

  NHTSA complaint · filed 07/29/2026

• “Mopar has discontinued parts for many Ram vehicles with a 6.4L Hemi motor including the exhaust manifolds. My exhaust manifold is currently cracked and has an audible leak. Exhaust enters the cab of the vehicle when starting, idling, or reversing. They have no indication of providing a fix for this and the parts are not available aftermarket either. This broken piece not only affects the performance and safety but renders my truck unusable per DOT guidelines and would be red flagged during a r…”

  NHTSA complaint · filed 08/18/2025

• “Complete engine failure at about 175000 miles, also transmission failure at about 125000 miles”

  NHTSA complaint · filed 04/28/2025

• “This vehicle has a manufacturers #X99 extended warranty. It is for the Turbo Actuator. It extends to 15 years or 150,000 miles. I had a failure of my Turbo Actuator. The vehicle went into limp mode approx 2,000 miles from my home.The malfunction indicator lamp went on and I had to get the control solenoid fixed in order to continue to use the vehicle. We were told that this was related to the Turbo Actuator and to get it fixed when we got back home. I had to have more work done on it once home t…”

  NHTSA complaint · filed 02/03/2024

• “Turbo Actuator for Ram 2500 has been recalled in 2022, but for some reason, my Ram 2500 from 2015 was left out of the recall. The MIL indication and subsequent codes related to this failure are the same as being reported in the Warranty Bulletin previously addressed by FCA, X99 6.7 Cummins Turbocharger Actuator Warranty Extension. I was put at risk of an accident due to this happening on expressway. I experienced a loss of power when I certainly needed it to pull over to get to the shoulder.…”

  NHTSA complaint · filed 09/18/2023

• “The high pressure fuel pump is disintegrating. It has been recalled in newer dodge rams But has not been recalled 4 2015 even though it is very similar and made of the same material. This has been confirmed with the dodge dealership as this is where it sits, so it is available upon request. We had a check engine light come on prior to the incident but was never Indicated when checked at the shop that this was the problem. As far as safety goes you never know when it is going to act up. It usuall…”

  NHTSA complaint · filed 06/15/2023

• “While my truck was parked and running (auto-started: FACTORY auto start), truck spontaneously burst into flames and burnt down before fire dept could get to it and put it out. TOTAL LOSS. Of note: fire dept was about 100yds away and responded as soon as we saw flames.”

  NHTSA complaint · filed 05/28/2023 · fire

• “On 3/29/23 while driving approximately 80 miles back home, the vehicle began leaking engine oil and coolant upon acceleration. The vehicle was returned to the shop for repair but the repair failed. On 4/8/23, again the vehicle began to spew oil and coolant upon acceleration. No warning lights came on. The reservoir for coolant is drained of coolant. There is an odor of oil and antifreeze in the cabin which is harmful and poisonous. Also, the engine may fail along with other components on the veh…”

  NHTSA complaint · filed 04/11/2023

Unverified owner reports from NHTSA's public complaint database.

Check the one you're looking at

A free VIN report shows recalls that may apply, the 5-year cost, and whether it fits your budget. Then ask our AI about this exact problem.