2016 Toyota Prius engine problems

What owners report

• “The front exhaust pipe assembly (heat exchanger) on my 2016 Toyota Prius leaked engine coolant internally into the exhaust system. Toyota has documented this condition in Technical Service Bulletin T-SB-0135-19 ("Low Coolant, MIL ON DTC P148F00, and/or Poor Heater Performance") for 2016-2019 Prius vehicles and released a redesigned replacement part (17410-37D40). In [October 2026], at about [97,000] miles, I found the engine coolant reservoir was emptying about every night (nearly a full reserv…”

  NHTSA complaint · filed 10/30/2026

• “Water pump failed without warning and caused irreparable damage to the engine ("blown" engine requiring replacement). Vehicle began to stall and not respond to attempted acceleration while traveling on 4 lane divided highway, 55 mph speed limit. One "Maintenance Required" message was received the previous week, but disappeared. This is the same message that appears for routine oil changes. No other warning messages were noted at the time of the incident, no unusual noises, and no smoke or ot…”

  NHTSA complaint · filed 03/13/2025

• “Refer to TSB 0135-19 dealer denied repairing under the California emissions defect and performance warranty.”

  NHTSA complaint · filed 01/25/2025

• “My car suddenly stopped in the middle of the road with message "Hybrid system stopped steering power low". Safety concern to this happen on the middle of road during rain or cold.”

  NHTSA complaint · filed 01/16/2025

• “During summer months when temperatures are above 100 degrees when accelerating from a complete stop I can hear the engine rev and the RPMs increase but the vehicle will move at 1-2 mph. Even if the accelerator is to the floor. After 3-4 seconds the tires will squeal and the vehicle will be jolted forward then it will slowly accelerate. This happens occasionally and I have taken it to a Toyota dealership and a chain mechanic shop, neither have been able to recreate the problem. There are no warni…”

  NHTSA complaint · filed 07/09/2024

• “We were driving kids to camp and the thermometer light went on. It was blinking for a while, then turned off and then turned steadily on. We weren't sure what to do, so we called our trusty mechanic who said "bring it in right now." We did and it turned out that this was a broken head gasket. Our car is regularly maintained by a trusted Prius mechanic and has less than 78K miles, despite its age. From our mechanic: We found the engine coolant was low in the radiator. We filled the system and …”

  NHTSA complaint · filed 06/08/2023

• “On September 2022 (at 46K) Dealer did TSB related fix on my 2016 Prius. PFA for service record. They replaced Exhaust Front Pipe, which is suggested work from Toyota PFA for Toyota Technical Bulletin. T-SB-0135-19 At 51,747 on March 1st 2023 around 8 40 am, while we are driving on highway at 70 mph suddenly Check Engine Light, Coolant light, Hybrid related lights were on Vehicle lost the control, speed was dropping luckily we could safely stop the vehicle on the shoulder no Vehicle hit us from …”

  NHTSA complaint · filed 03/07/2023

• “Shortly after having my Toyota serviced, I had an engine coolant warning sign appear. I checked and noted the coolant was gone. I bought coolant and filled the coolant tank. A week later, I see the light again. I have seen no leakage at all on the ground. I refilled the coolant and checked again the next morning. Again the tank is empty. I took the car to a local reputable service person and thus far, he sees no leakage outside of the car. This suggests to him a bigger problem, where the coola…”

  NHTSA complaint · filed 08/23/2022

Unverified owner reports from NHTSA's public complaint database.

Check the one you're looking at

A free VIN report shows recalls that may apply, the 5-year cost, and whether it fits your budget. Then ask our AI about this exact problem.